RFI - Att 3 - EZGREY Manual

Page 2

  
  

‘ AWWS EZGREY
System

Greywater Diverter
OIM Manual

Operation - Installation - Maintenance

 

Grey Water Reuse System
[_] EZGREY (GF-EZ)

——

“Moving NACo www.greyflow.net.au

   
 

Page 3

Contents:

OPERATION:

Selection & Operation Page 3
Requirements Page 4
INSTALLATION:

Parts list & Components Page 5
Important Do's and Don'ts Page 6
Operating Modes Page 7
Step One: EZGREY tank positioning Page 8
Step Two: Plumbing and power connection Page 9
Step Three: Installing the irrigation system Page 10-11
MAINTENANCE Page 12
TERMS OF WARRANTY Page 13
DISCLAIMER Page 14

Eee

a COLUCU WAN www.greyflow.net.au

      

Page 4

Selection and Operation

Congratulations, You've taken an important step towards envi-
ronmentally friendly living with your purchase of the EZGREY
greywater diversion and reuse system.

The EZGREYSystem was developed for above ground / partially
buried installations and can be retrofitted into almost any house.

In some parts of the world the EZGREY is known as the auto-
matic bucketting system, and has been used extensively in
drought striken areas to keep garden green, save water, and
beat water restrictions.

Please note: Due to its high fat content, water from kitchen is
harmful to soils, and is not considered suitable for reuse in
gardens with the EZGREY system.

Manual diversion of the Grey Water to sewer is achieved through
the 50mm 3-way valve and manifold supplied with the unit.

a COLUCU WAN www.greyflow.net.au

 

Page 5

Requirements

- The water discharge should be kept below mulch or soil (check for local state,
municipal & council laws and regulations)

- 220Volts power supply should be available

- The EZGREY can be turned off during wet conditions and any sign of accumulation
or run-off

-  Allminimum irrigation areas and set back distances must be in accordance to local
regulations

- Table 1.0 provides an estimated average volume of greywater that is generated in
various parts of the house. Refer to your greywater state guidelines to evaluate
your minimum irrigation area requirements.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Table 1.0

eam eC LCC et

AComt stew oath ted People LS SST
Laundry Only Whole of House Laundry House Laundry House

Sandy 122 | 30 24 60

2, 3 120 300 Loamy 18 45 36 90
Clay 24 60 48 120

Sandy 16 40 32 80
3 4 160 400 Loamy 24 60 48 120
Clay Ba 80 64 160
Sandy 20 50 40 100
4 5 200 500 Loamy 30 7 60 150
Clay 40 100 80 200
Sandy 24 60 48 120
5 6 240 600 Loamy 36 90 72 180
Clay 48 120 96 240
Sandy 28 70 56 140
6 i) 280 700 Loamy 42 105 84 210
Clay 56 140 112 280
Sandy 82 80 64 180
7 8 320 800 Loamy 48 120 96 240
Clay 64 160 128 320

 

 

 

 

 

 

 

 

 

 

 

 

Page 6

Parts List & Components

The G-Flow Complete System is supplied with:

1x Corflute Greywater cree

warning sign a ___ [tis Proverry

1x EZGREY lid cover ——————__ wat

 
  
   
  

1x Graded lint fi Iters TT

(+1 extra set for easy swap over) 1x50mm overflow

ee a manifold

a
el Ds

 

1x Inlet manifold

1x 50mm 3-way valve

1 x EZGREY tank

1x Submersiblepump = ~——————_

with vertical float switch

 

Page 7

Important Do’s and Don’ts

Never operate the EZGREY system without the filter firmly positioned in place

 

Quick connect
camlock fitting

Filter set

 

See As www.greyflow.net.au

 

Page 8

Operating Modes

{— EZGREY in shut off mode \

The greywater

 

Greywater inlet ="
=a |

3-Way valve handle is in the
horizontal position, EZGREY
is in shut off mode and the
greywater overflows to sewer

XY

 

 

3-Way valve handle is in the
vertical position, Greywater is
forced through the filters into
the pumped out chambers

 

 

 

The greywater
overflows to sewer

3-Way valve handle is in the
vertical position and allows
water in the EZGREY.

The filters are blocked, water
overflows back to sewer via
the overflow opening

LEU ASCs www.greyflow.net.au

 

Page 9

Step One: EZGREY Tank Positioning

   

Option 1:
Above ground option

Option 2:
Below ground option

(in paving or garden bed area)

 

 

Page 10

Step Two: Plumbing and power connection

Outdoor GPO

 

EZGREY Size:
Height 0.6m
Width 0.4m
Depth 0.4m

 

 

Option 1: Option 2:
(Additional piping and fittings are not included)

Greywater
inlet

   

 

Greywater
inlet

a

Greywater
overflow

See As www.greyflow.net.au

   

Page 11

Step Three: Installing the Irrigation System

Option 1: Single Station EZGREY with GF Drip-Tube Kit

i ue Ha

   

—_ Minimum pipe
size 1”

1.25mm or larger feeder pipe

2. Coil of GF Drip-Tube around
trees

3, Elbow take-off adaptor

4. 16mm GF Drip-Tube (no
more than 7m length

5.25mm flush manifold

6. Manual flush valve

 

GREY WATER
IN USE ON
THIS PROPERTY

Greywater Warning Sign
to be visible at all times

*Use of a non Grey Flow dripline will void the system warranty

 

Page 12

Step Three: Installing the Irrigation System

Option 2: Multi station distribution using GF Rotor

Greywater Warning Sign
. to be visible at all times
Use GF Rotor flow based indexer GREY WATER E f
to split the system into more IN USE ON (x) OX)
than one station. Up to 6 stations. THIS PROPERTY

fe
f

LN Q ®

2 or more stations x) (x) :

can be joined to form é
a single station

Make a hole with (x)
punch tool & insert ,
drip tube takeoff

Minimum of 4 and 2
r oO maximum of 8 trees «)

per station (one emitter

, ; per tree)
1" Low density poly . «) When using driplines make
supply pipe. (Not supplied ‘ sure to adhere to the max «) '
with the system. To be run length of 7 yards per
purchased separately) take-offs

® ® ® ® we

3 8

 

 

 

 

 

Page 13

Maintenance

To retain the original reliability and performance of the EZGREY System
the following maintenance procedure should be followed. Please ensure
that you wash your hands thoroughly after contact with Greywater or
handling any part of the EZGREY System.

The following maintenance steps should be carried every 3

months and not less than once every 6 months:

- Open top cover of the EZGREY tank

- Remove primary sponge filters and wash thoroughly in a bucket, with a
garden hose or in any basin not connected to the dedicated Greywater
line

- Re-insert the filter in its original position, close the lid of the tank
and the EZGREY System is ready to operate again.

The following maintenance steps should be carried out once a

ear:

» Open top cover of the EZGREY tank

- Remove the primary sponge filters and wash thoroughly in a bucket,
with a garden hose or in any basin not connected to the dedicated Grey
water line.

- Wash thoroughly the tank with a garden hose and drain the tank using
the pump to discharge to a sewer outlet (the irrigation system should be
disconnected during this process)

- Disconnect the EZGREY pump and connect the supplied going away
backup quick connector.

- Flush the Grey Flow emitters with fresh water for about five minutes.

- Re-insert the filter, reconnect the pump, close the lid of the
EZGREY tank and the EZGREY system is ready to operate again.

- Top up mulch over the Grey Flow emitters to a minimum depth of
100mm.

 

Page 14

Limited Consumer Warranty

ADVANCE WASTE WATER SYSTEMS

Two Year Limited Warranty
Advance Waste Water Systems (AWWS) warrants this product against material defects in mate-

rials and workmanship for a period of TWO YEAR from the date of the original retail purchase
(warranty period). Warranty work will be done in accordance with the following terms and con-
ditions. This warranty only benefits the original purchaser.

THIS WARRANTY COVERS ONLY DEFECTS IN MATERIAL AND
WORKMANSHIP. THIS WARRANTY DOES NOT COVER ANY OF
THE FOLLOWING:

1. Expendable items that can wear out from normal use, including but not limited to, filters,
or similar perishable parts.

2. Damage to or failure of this system if it is not installed, operated, or maintained
according to all instructions supplied with the system.

3. Damage to or failure of this system resulting from accident, abuse, misuse, or
use for other than its intended purpose, Act of God.

4. Damage to or failure of parts or system resulting incomplete or improper instal-
lation or from unauthorized modifications made to this system.

5. Ifyou purchase the system from an unauthorized retailer or dealer.

6. Damage caused by power surges, electrical storm damage, incorrect power
supply, or insect or vermin infestation

7. Damage to or failure of parts if this system is serviced or rapaired by anyone
other than an Authorized Service Center.

8. This warranty extends only to you, the original purchaser. It is not transferable to anyone
who subsequently purchased this product from you.

9. Use for more than a single family or use in a commercial establishment or for
commercial non-household purposes.

10. Parts and systems not supplied by AWWS are not covered by this warranty

Any item which has been repaired or replace under this warranty shall
be covered for the remainder of this original warranty as extended by
the number of days that the product has been out of your hands for
repair.

 

Page 15

Disclaimer

Disclaimer of implied warranties; Limitation of remedies

1. All implied warranties, including implied warranties of merchant ability and fitness for a particular purpose,
are limited in duration to one year from the date you purchased the product.

2. Neither AWWS nor its affiliates are responsible or liable for any loss, inconvenience or damage, whether
special, exemplary, direct, incidental, consequential or otherwise, and whether known or should have been
known to AWWS including damage to or replacement of other equipment and property and personal injury
resulting from any breach of warranty, the inability to use the product or under any legal theory in contract or
tort. There warranties and remedies are the sole and exclusive warranties and remedies given by AWWS in con-
nection with the sale and use of the product. No other warranties, oral or written, express or implied are given.

3. Inany event, AWWS's entire liability shall be limited to the actual purchase price you paid to the retail seller
of the defective product. This limitation applies whether damages are sought or a claim made, under this
warranty or as a tort claim (including negligence and strict product liability), a contract claim or any other claim.
This limitation cannot be waived or amended by any person. This limitation of liability is effective even is AWWS
or any authorized repre sentative of AWWS has been advised by you of the possibility of such damages. This
limitation of liability, however, shall not apply to claims of personal injury.

4.No AWWS dealer, agent or employee is authorized to make any modification, extension, change or amend-
ment to this warranty.

YOUR RESPONSIBILITY

The above limited warranties are subject to the following conditions:

You must provide your original bill of sale, invoice or other proof of purchase of the system showing that you
are the original purchaser, that the purchase was made within two years of the date of your claim and that you
purchased it from an authorized dealer or retailer. No warranty ee will be done without this information.
Keep a copy of your receipt or invoice for your own records. These limited warranties are effective only if this
system is purchased and used in AU region Labor and service charges for warranty repair, installation, set up,
and adjustment of customer control are not covered by these limited warranties. Should you encounter a
defect in the system, www.greyflow.net.au to find the closest authorized service center. Contact the center and
itwill arrange for an inspection and corrective action, if needed and if covered by this warranty.

Should the center determine that the system is not covered by this warranty; any corrective work will be per-
formed at your request and at your expense. If the center makes a second and/or subsequent visit and deter-
mines that there is no problem or that the system is not covered, the service call will be charged to you.

When making a warranty clain, please be prepared to provice a description of the system, your name, address,
Ne eae Sevier number, a description of the problem, the date you purchase the system and the identity
of the seller.

“moving Nee yA www.greyflow.net.au

 

Page 16

 

Advance Waste Water Systems Pty Ltd
P.O. Box 561, Floreat, WA6014

Mob: 04-0545-9533

Tel: 08-9467-5990 r( AWWS
Fax: 08-9309-2304 Advanced Waste Water Systems

Email: [email protected]
www.greyflow.net.au

www.greyflow.net.au

ar U Renae

 

Page 17

a

G

STRATEGIC

STRATEGIC SOLUTIONS,
CREATIVE THINKING

rgstrategic.com.au